Stator Went Bad Again After Replacement
Making sure that your outboard is running and reliable. Makes all the divergence in your feel out on the water. Having a bad stator is going to take away from that experience!
Will An Outboard Run With A Bad Stator? Yep, certain outboards will run with a bad stator, merely not very well. No, other smaller outboards will not run with a bad stator. The stator produces the electricity that the engine uses to operate the ignition system to run the engine.
There are many different factors and variables to this question! Here are all of the things that you need to know to figure out which of them applies to you lot!
What Exactly Is A Stator?
A stator is a component on an engine that is attached under the flywheel of the engine. The engine'south flywheel has magnets attached to the inside of it, that spin around the stator.
The stator is fabricated up of windings that produce alternating current electricity. As the magnets on the flywheel spin around the windings when the engine is running.
This AC electricity is used by the engine to run all of the ignition components of the engine. That makeup is what creates the spark for the engine to run.
For a more in-depth description of how an engine works. Read our commodity teaching you lot What Is A Powerhead & How It Works!
A stator is also the component that creates the charging power for your boat'due south batteries. If the stator fails, and so yous won't be charging your boat'southward batteries while you are running!
Nosotros'd recommend reading this commodity here on How Outboards Accuse The Boats Batteries By Either A Stator or An Alternator.
Signs & Symptoms Of A Bad Stator
A bad stator tin accept all kinds of funny, hard to trace symptoms. Making it sometimes difficult to diagnose.
Information technology's important to note what kind of engine yous are working on. Since the stator is what creates the electricity needed for the engine to create a spark and run.
Smaller outboards that only take ane, or two cylinders. It will not even commencement and run if the stator has failed!
Whereas larger engines, that take four, 6, or 8 cylinders. Volition employ a stator that has different parts to it.
Some stators will exist broken down into 2, three, four, or even half dozen halves! Significant, that ane winding will produce the electricity that is used for i, 2, or iii different cylinders!
And so, if i winding will fail. The engine will lose spark on one or all of those cylinders. Making the engine run very poorly.
This is why you tin can take a bad stator, only the engine will notwithstanding run, only very poorly.
Why Do Outboard Stators Get Bad?
There are many reasons for a stator to go bad. They go quondam, they become hot, they break down, and they just apartment out become bad!
If the windings go corroded by a dirty engine, they can fry themselves. Or brusque out. So a dirty engine can cause a stator to go bad. As well as running as well hot.
Say you wrap a handbag effectually the lower unit and loose cooling h2o. Or if the thermostat gets chock-full with weeds, dirt, or sand. Then the engine runs warmer than it should.
If that is left like that and you don't address the issue. The warm temperature can melt parts of the stator. Causing information technology to neglect!
I would say that the primary crusade for a stator to get bad, is due to historic period, estrus, and corrosion. Those are the three chief causes for a stator to fail.
How Do I Know If My Stator Is Bad?
You lot tin tell the stator is bad, based on the symptoms of the engine. Though it won't be a clear and cut state of affairs. You will demand to test the stator and we'll cover that in a 2d.
Yous can know you accept a bad stator by looking at it. If the stator is covered in common salt and corrosion. Or you see information technology has melted or burnt windings on it. Then you lot could virtually bet that information technology is bad.
Earlier condemning it though, you desire to perform some tests to be exactly sure that the stator has failed.
How To Test An Outboard Stator
When it comes to testing the stator. Y'all should be aware that unlike manufacturers are going to have unlike tests, different readings, and different styles of stators.
Merely, in the general sense, there are some tests that yous tin do on almost whatever stator and tell a lot of whether it has failed or not.
The number i test is to ground information technology out. In social club to perform this examination. You will need to accept a digital multi-meter. (You can see our recommendations for a meter on our resources page hither.)
What y'all will do, is find the plug that goes to the stator. Then disconnect it. With that disconnected. You tin ready the meter to read ohms or resistance.
Then connect the negative meter lead to any engine ground that is on the block. And take the positive meter lead and bank check for a brusque to ground at each and every wire that is coming out of the stator.
If y'all find that there is continuity between the wire going to the windings in the stator. And so you know that the stator is shorted to basis and you will need to replace the stator.
Then, on other stators, y'all tin can bank check the resistance between the wires coming out of the stator. Some of these stators volition accept a certain amount of resistance between the wires.
And others volition have direct continuity between the wires. This is why it is of import for you to find the service manual for the specific engine you are trying to test the stator on.
And go by the specs found in the book to test the stator. Because there is too a voltage reading that can be performed to see what kind of power the stator produces.
But you volition need to take a digital voltage adapter to test this to keep the fuses in your meter from blowing. And so be certain to examination your engine'south stator based on the service manual specs and tests!
Will An Outboard Run Without Stator?
Information technology depends on what style and type of engine yous have. Equally we said earlier.
In that location are some larger engines that volition run with a partially bad stator. While in that location are other smaller outboards that volition definitely non run without it.
So information technology all depends on your engine and what kind of system information technology uses!
Check U.s. Out!
Now that you know all about outboard stators and how to test them. Here are some other articles that you will find extremely helpful and informational!
Why Does My Boat Battery Keep Dying? How To Prepare Information technology!
Why Won't My Outboard Boat Engine Turn Over!?
How Long Practice Boat Batteries Terminal? And How to Make Them Terminal Longer!
We'd as well like to invite yous to bank check us out on Our YouTube Channel! We create all kinds of how-to and DIY videos. To help you lot acquire more than and more well-nigh your gunkhole and how it works!
If you've got whatsoever questions or comments, let us know by subscribing to our YouTube Channel!
And if you would like to support usa to go along bringing y'all peachy content, please click the link beneath to Amazon where we go a commission from anything y'all are already going to purchase!
Click Here To Amazon!
And y'all can also donate by clicking the donate push here or on the right hand of the screen!
It really helps united states out and we thank you then much for your support!
Thanks for reading and we expect forrard to reading your responses and comments.
Source: https://www.bornagainboating.com/bad-stator/
0 Response to "Stator Went Bad Again After Replacement"
Post a Comment